Custom Boat Manual

Models › Hallberg-Rassy

Hallberg-Rassy 31

Built 1992–2009 by Hallberg-Rassy (Ellos, Sweden)

Own one? Keep her maintenance, manuals and checklists here — free Shopping? Find the right used boat

About the Hallberg-Rassy 31

Researched from public sources for this model. Any individual boat may have been modified or repowered — confirm before relying on any figure.

Illustration of a Hallberg-Rassy 31
Illustration, not a photo of this model. AI-generated illustration of a typical mid-size cruising sloop.
Built
1992–2009
Builder
Hallberg-Rassy (Ellos, Sweden)
Designer
German Frers
Length
31.56 ft
Waterline
27.1 ft
Beam
10.83 ft
Draft
5.61 ft
Displacement
9,921 lb
Ballast
4,409 lb
Hull / keel
fin keel
Rig
sloop
Fuel
16 gal
Water
50 gal
Number built
356
Stern thruster
none

Fractional sloop, spade rudder, lead ballast; shoal keel 4.62 ft. Later boats had the Volvo 2020. Early 1992 boats had no fixed windshield. Drive type (shaft or saildrive) not stated in sources read.

Known problems for this model

No well-sourced problem reports found yet.

Engines & parts

Volvo Penta 2001 / 2002 / 2003 / 2003T parts: limited

Factory standard engine — you entered “Volvo Penta 2002”

Parts are available through Volvo Penta but owners consider them unique and overpriced (e.g., 2003T turbo, aluminum heat exchanger and oil cooler each quoted in the $1,700–3,000 range). Workarounds include converting the 2003T cooling system to aftermarket cupronickel heat exchanger and oil cooler, using the common aftermarket turbo, and cross-referencing some Perkins parts. Parts4Engines stocks aftermarket service parts.

Parts sources: Parts4Engines, Power Products Systems (genuine Volvo Penta parts)

Common problems (3)
  • Aluminum oil cooler and heat exchanger failures (2003T) cooling
    The aluminum oil cooler and heat exchanger are the usual first failures, and genuine replacements are very expensive, so some owners convert to aftermarket coolers or repower.
    cruisersforum.com · facebook.com
  • Carboned exhaust elbow and turbo from low-load running exhaust
    Long periods at low rpm carbon up the elbow and the 2003T turbo; the turbo can also be wrecked if it ingests the intake silencer foam.
    cruisersforum.com
  • Hard starting on older raw-water-cooled 2002s engine
    Original raw-water-cooled 2002s are described as reliable but difficult to start.
    forums.ybw.com
Model sources (1)

sailboatdata.com

Other Hallberg-Rassy models

Researched from public sources. Spotted an error? The sources are listed above — tell us what they got wrong.