Carver 370 / 374 Voyager
Built 1993–2002 by Carver Yachts
Own one? Keep her maintenance, manuals and checklists here — free for a week
Shopping? Find the right used boat
Looking at one? Sea-trial scorecard
About the Carver 370 / 374 Voyager
Researched from public sources for this model. Any individual boat may have been modified or repowered — confirm before relying on any figure.
- Built
- 1993–2002
- Builder
- Carver Yachts
- Length
- 37.08 ft
- Beam
- 13.25 ft
- Draft
- 3.67 ft
- Displacement
- 21,350 lb
- Hull / keel
- planing
- Propulsion
- inboard
- Fuel
- 297 gal
- Water
- 83 gal
- Holding
- 35 gal
- Stern thruster
- not fitted
Tank capacities — where the figures come from
-
Fuel 297 gal
No figure found in any builder, owners-group or magazine source.
-
Water heater unknown
No builder document, review or listing giving the heater size found.
Tanks are often replaced or added on older boats — check the tank labels or a survey for yours.
Thrusters and steering — where this comes from
-
Bow thruster unknown
An owners'-forum thread discusses an external bow thruster on a 1996 Carver 370 aft cabin, but what could be read of it doesn't show whether one came from the factory.
-
Stern thruster not fitted
Our earlier figure of none has no source, and nothing was found either way.
-
Steering unknown
A generic Carver owner's manual (model not identifiable) describes Hynautic hydraulic steering with a pressurized reservoir, but it can't be tied to the Voyager. The 1993 owner's guide and 1997 parts manual couldn't be checked.
Thrusters and steering are often replaced — check the units on your boat before ordering parts.
Sources disagree on hp (Crusader 454 gas) — left blank rather than guessed.
Tri-level pilothouse layout; interior revised in 1999 (salon moved forward to bridge-deck level), styling updated 2000. Most have a lower helm. Named 374 Voyager in the final year (HMY text garbles the dates).
Engines fitted
-
Crusader 454 (7.4L) gas V8 — 350 hp, gas, twin
standard
HMY: 350 hp Crusader gas engines cruise at 16-18 kn. A 1994 boat lists twin freshwater-cooled Crusader 454s but rates them 310 hp (see disputed).Sources: hmy.com · harbortownemarine.com
-
Volvo Penta 230 hp diesel (model not named by source) — 230 hp, diesel, twin
factory option
HMY: optional 230 hp Volvo diesels cruise about 18 kn.Sources: hmy.com
-
Cummins 6BTA 5.9 — 220 hp, diesel, twin
factory option
HMY lists 220 hp Cummins as the alternative diesel; a 2001 Voyager 374 lists twin Cummins 6BTA at 220 hp.Sources: hmy.com · bayviewyachts.com
Boats of the same model can differ — check which engines yours actually has before ordering parts.
Generator
Single listings only: a 6.5 kW Onan on a 1994 gas boat and an 8 kW Kohler diesel on a 1993 twin-diesel boat. No Carver option list or review was found; a 1999 Carver spec sheet exists but is only sold by a brochure dealer.
Known problems for this model
-
Bottom laminate failure reported hull
A trawler-forum surveyor account describes severe bottom-laminate delamination on a 1994 Carver 370 (variant not stated); treat the bottom as a key survey item.trawlerforum.com
Engines & parts
Crusader 350 / 454 inboard gas V8 parts: good
Factory standard engine — you entered “Crusader 454 (7.4L) gas V8”
GM-based inboard engines; Crusader (now part of Pleasurecraft Marine Engine Co.) still publishes illustrated parts manuals and sells through distributors. Go2marine stocks Crusader manifolds, risers, raw water pumps and ignition parts; Osco and Barr make aftermarket manifolds, and new GM/Crusader base engines are sold by rebuilders.
Parts sources: Crusader Engines, Go2marine (Crusader parts), 1-800-RUNS-NEW (GM & Crusader base engines)
Common problems (1)
-
Clogged or failing manifolds/risers exhaust
Owners find individual risers running much hotter than the others (a sign of internal blockage) and debate replacing vs. flushing; Osco manifolds are often preferred as closest to OEM.marineengine.com · marineengine.com
Maker’s service schedule (14)
| Engine oil & filter change 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 1 yr | “Change engine oil and filter — After 1st 25 Hrs / Every 50 Hours of Operation / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Fuel filters & water separator 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 1 yr | “Fuel Filters - Service or replace — After 1st 25 Hrs / Every 50 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Raw-water pump impeller 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Cooling System - Inspect/Replace raw water pump impeller — Every 100 Hours of Operation / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Drive belts inspect / replace 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Drive Belt - Inspect condition and check tension — After 1st 25 Hrs / Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Spark plugs inspect / replace 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Ignition System and Spark Plugs - Clean and inspect condition — After 1st 25 Hrs / Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Exhaust mixing elbow inspection 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 4 mo | “Exhaust System - Check condition and tightness of all hose clamps — After 1st 25 Hrs / Every 100 Hours(1) / Once Each Ye” — manufacturer (2013), crusaderengines.com |
| Coolant replacement & freeze-point test 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 5 yrs | “Fresh-water cooled models - Change coolant — Every five years” — manufacturer (2013), crusaderengines.com |
| Engine pencil zincs 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 mo | “Zinc Anodes - Heat exchanger and cooler - check condition — Every 30 days” — manufacturer (2013), crusaderengines.com |
| Transmission fluid change 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 yr | “Transmission and "V" Drive - Change fluid and clean strainer, if equipped — After 1st 25 Hrs (Hurth Only) / Once Each Ye” — manufacturer (2013), crusaderengines.com |
| Flame arrestor & crankcase ventilation - clean and inspect 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Flame Arrestor and Crankcase Ventilation System - Clean and inspect — Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Engine alignment check 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 yr | “Engine Alignment - Check and adjust if necessary — After 1st 25 Hrs / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Inspect all hoses (and cooling hose clamps) 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Hoses (all) - Inspect for cracks, swelling, weather checking or other signs of deterioration — Every 100 Hours / Once Ea” — manufacturer (2013), crusaderengines.com |
| Shift & throttle cable linkage - inspect and lubricate 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 4 mo | “Shift and Throttle Cable Linkage - Inspect and lubricate — Every 100 Hours(1) / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Electrical system - check connections and wiring 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 2 mo | “Electrical System (complete) - Check for loose or dirty connections and damaged wiring — Every 50 Hours(2) / Once Each Y” — manufacturer (2013), crusaderengines.com |
Service part numbers (18)
| Oil filter remote-mounted oil filter (MP7.4L and 2013 5.0/5.7/6.0L MPI) |
Crusader 22679 | “Oil Filter 22679 (MAINTENANCE ITEM PART NUMBERS)” — manufacturer, crusaderengines.com |
| Fuel filter MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 |
Crusader 47038 | “Fuel Filter 47038 (MAINTENANCE ITEM PART NUMBERS)” — manufacturer, crusaderengines.com |
| Fuel filter 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13 |
Crusader RP080026 | “Fuel Control Cell (FCC) Fuel Filter Element RP080026” — manufacturer, crusaderengines.com |
| Fuel pre-filter / separator MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: engine-mounted Racor water-separating filter 47046 |
Crusader 47047 | “25 47047 Element, Racor fuel filter (Not Shown) 1” — manufacturer, crusaderengines.com |
| Fuel pre-filter / separator 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13: primary fuel filter |
Crusader R080033 | “Primary Fuel Filter Element R080033” — manufacturer, crusaderengines.com |
| Raw-water impeller MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 (raw water pump RA057031) |
Crusader RP061017 Replaces R061017 |
“Replaces Crusader R061017 (Impeller Kit with Gasket & O-Ring | Crusader RP061017)” — dealer, marinepartssource.com · “Replaces Crusader R061017 (Impeller Kit with Gasket & O-Ring | Crusader RP061017)” — dealer, marinesuppliesdepot.com |
| Raw-water impeller 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13 |
Crusader RP061022 | “Impeller , Raw Water Pump (1) RP061022 (ON-BOARD PARTS KIT 5.7L)” — manufacturer, crusaderengines.com |
| Raw-water pump kit MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 (raw water pump RA057031) |
Crusader 40064 | “40064 Overhaul Kit, Major (includes items 2, 3, 11, 14 and 15)” — manufacturer, crusaderengines.com |
| Drive belt MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: alternator drive |
Crusader 98210 | “Alternator Drive Belt 98210” — manufacturer, crusaderengines.com |
| Drive belt MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: raw water pump drive |
Crusader 10258 | “Raw Water Pump Drive Belt 10258” — manufacturer, crusaderengines.com |
| Drive belt 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, left-hand (LH) rotation: serpentine |
Crusader R066028 | “Belt , Serpentine (1) R066028 (ON-BOARD PARTS KIT 5.7L (LH))” — manufacturer, crusaderengines.com |
| Drive belt 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, right-hand (RH) rotation: serpentine |
Crusader R066029A | “Belt , Serpentine (1) R066029A (ON-BOARD PARTS KIT 5.7L (RH))” — manufacturer, crusaderengines.com |
| Spark plug MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: platinum plug |
Crusader 49078 × 8 | “Spark Plugs (platinum) 49078” — manufacturer, crusaderengines.com |
| Spark plug 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13: platinum plug set |
Crusader RP030010 | “Spark Plug , Set, (Platinum) (1) RP030010 (ON-BOARD PARTS KIT 5.7L)” — manufacturer, crusaderengines.com |
| Thermostat MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: raw-water (standard) cooling, 143 F |
Crusader R026002E | “6 R026002E Thermostat (143-degree) 1 (Raw Water Cooling Components - Figure 18)” — manufacturer, crusaderengines.com |
| Thermostat MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: fresh-water (closed) cooling kit, 170 F |
Crusader 98203 | “5 98203 Thermostat (170-degree) 1 (Fresh Water Cooling Components 1)” — manufacturer, crusaderengines.com |
| Zinc / anode MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: oil cooler / transmission cooler / heat exchanger |
Crusader R168005 | “24 R168005 Zinc, sacrificial 1 (Raw Water Cooling Components - Figure 18)” — manufacturer, crusaderengines.com |
| On-board spare parts kit (belt, cap, rotor, fuses, relays, plugs, impeller, fuel filters) 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, LH rotation |
Crusader RK173089D-07 | “ON-BOARD PARTS KIT 5.7L (LH) 2007 TO PRESENT, FCC FUEL SYSTEM RK173089D-07” — manufacturer, crusaderengines.com |
From the engine maker’s parts lists, or two independent parts dealers. Numbers change with serial number and get superseded — check yours before ordering.
Cummins 6BT / 6BTA 5.9 parts: good
Factory optional engine — you entered “Cummins 6BTA 5.9”
Mechanically injected 5.9 L inline six from the Cummins B-series truck/industrial family, so base-engine parts are everywhere. Cummins still sells factory ReCon (remanufactured) marine 6BT/6BTA engines (152–210 hp ratings) with a 2-year/2000-hour warranty. Seaboard Marine is the best-known marine specialist, selling aftercooler/heat-exchanger service kits, upgraded raw water pumps and technical guidance; TAD also sells Cummins packages.
Parts sources: Seaboard Marine, Cummins (ReCon 6BT/6BTA), Diesel Pro Power
Common problems (2)
-
Aftercooler corrosion letting seawater into the intake cooling
On the turbo-aftercooled 6BTA the seawater-cooled aftercooler core has vertical tubes and an aluminum housing that corrodes from condensate; a leak can put salt water into the cylinders and wreck the engine. Owners pull, clean, grease and pressure-test the core every few years and fit new O-rings.trawlerforum.com · sbmar.com
-
Heat exchanger and aftercooler service cooling
Routine seawater-side service (O-rings, gaskets, zincs) is a recurring owner job; kits are sold for it and refilling coolant without trapping air is a common question.sbmar.com · sbmar.com
Service part numbers (5)
| Oil filter | Cummins 3937743 | “| Oil Filter | 3937743 |” — dealer, marineenergy.com.au · “Cummins Oil Filter 3937743 Spin-on type, 3.66" outside diameter, 6.95" height” — dealer, dieselpro.com |
| Fuel filter 6BT 5.9 210 hp (CPL 742) |
Fleetguard FF5052 Replaces FF42000, FS1251 |
“on-engine fuel filter with drain for all 6BT 210 B’s (CPL 742). Replaces the FF42000, FS1251.” — dealer, sbmar.com · “Cummins 6BT Fuel Filter 3931063 FF5052” — dealer, marineenergy.com.au |
| Fuel filter late 6BTA (also late 4BTA and 6CTA) |
Fleetguard FF5285 | “Fleetguard FF5285 Fuel Filter – late 4BTA 6BTA and 6CTA’s” — dealer, sbmar.com · “Cummins 6BTA Fuel Filter 3890017 FF5285 ... suits late model Cummins 6BTA's, 6CTA8.3-M” — dealer, marineenergy.com.au |
| Raw-water impeller seawater pump with 1-1/4 in hose ports (Sherwood M70/M71 type, early 4BT/6BT) |
Sherwood 10615K | “Seawater Pump Impeller | **1-1/4" PORTS** 3908220 10615K” — dealer, marineenergy.com.au · “Cummins Marine Water Pump Impeller 10615K 2 9/16" diameter, 1 5/8" length” — dealer, dieselpro.com |
| Raw-water impeller keyway-shaft pump, 2 in inlet / 1-3/4 in outlet, 11° offset flange (e.g. P1716/P1730 on 6BTA) |
Sherwood 17000K | “**2" inlet & 1-3/4" outlet ports with 11° OFFSET flange** 17000K” — dealer, marineenergy.com.au · “Cummins Impeller for Key Shaft 17000K” — dealer, dieselpro.com |
From the engine maker’s parts lists, or two independent parts dealers. Numbers change with serial number and get superseded — check yours before ordering.
Model sources (4)
hmy.com · trawlerforum.com · harbortownemarine.com · bayviewyachts.com
Own a Carver 370 / 374 Voyager? Add her to your boats, then share a photo — names, numbers and faces are blurred before it appears.
Other Carver models
- Carver 3207 Aft Cabin 1983–1990
- Carver 3297 Mariner / 330 Mariner 1985–1996
- Carver 355 / 356 Motor Yacht 1995–2003
- Carver 390 / 400 / 404 Cockpit Motor Yacht 1993–2003
Researched from public sources. Spotted an error? The sources are listed above — tell us what they got wrong.