Carver 390 / 400 / 404 Cockpit Motor Yacht
Built 1993–2003 by Carver Yachts
Own one? Keep her maintenance, manuals and checklists here — free for a week
Shopping? Find the right used boat
Looking at one? Sea-trial scorecard
About the Carver 390 / 400 / 404 Cockpit Motor Yacht
Researched from public sources for this model. Any individual boat may have been modified or repowered — confirm before relying on any figure.
- Built
- 1993–2003
- Builder
- Carver Yachts
- Length
- 40.17 ft
- Beam
- 13.25 ft
- Draft
- 3.25 ft
- Displacement
- 24,300 lb
- Hull
- fiberglass
- Hull / keel
- planing
- Propulsion
- inboard
- Water
- 70 gal
- Holding
- 36 gal
- Stern thruster
- not fitted
Tank capacities — where the figures come from
-
Fuel unknown
“standard 280 gallon fuel capacity” — review, denisonyachtsales.com · “optional fuel tank that increased capacity to 340 gallons” — review, denisonyachtsales.com · “fuel tank 318 Gallon(s) - 1 tank(s)” — search excerpt (1994), machinio.com · “Fuel: 336 gals.” — search excerpt (1993), westwindyachtscanada.comA Sea Magazine boat test (reprinted on a broker's site) gives 280 gal standard, or 340 with an optional tank; listings show 318 and 336. Our earlier 318 came from a spec database, and no builder figure settles it.
-
Water 70 gal
“70 gallon water tank” — review, denisonyachtsales.com · “fresh water tank 70 Gallon(s)” — search excerpt (1994), machinio.comThe magazine test and a listing agree (the magazine also lists an 11-gal water heater, not counted here).
-
Holding 36 gal
“Each head has its own 18 gallon holding tank” — review, denisonyachtsales.com · “Waste: 36 gals.” — search excerpt (1993), westwindyachtscanada.comTwo 18-gal tanks, 36 gal in total; the magazine test and a listing agree.
-
Water heater unknown
No builder document, review or listing giving the heater size was found. This model is a cockpit version of the 355/356; see that entry.
Tanks are often replaced or added on older boats — check the tank labels or a survey for yours.
Thrusters and steering — where this comes from
-
Stern thruster not fitted
Our earlier figure of none has no source, and nothing was found either way.
-
Steering unknown
No builder, owners' or review source describing the steering was found. The HMY powerboat guide notes this is a 355/356 Motor Yacht with a cockpit, so the two likely share systems, but neither has a source.
Thrusters and steering are often replaced — check the units on your boat before ordering parts.
Sources disagree on fuel tank — left blank rather than guessed.
Named 390 CMY (1993-95), 400 CMY (1996-98), 404 CMY (1999-2003). Essentially a 355/356 Motor Yacht with a cockpit; solid fiberglass hull; cockpit reached from the master stateroom or aft deck.
Engines fitted
-
Volvo Penta 7.4L gas V8 inboard (740 / 7.4 GI) — 310 hp, gas, twin
standard
HMY: among several engine options, Volvo 310 hp gas inboards cruise at 16-18 kn. A review of the 390 reprinted by Denison lists a pair of Volvo Penta 740s among the gas choices. Which gas engine was the base package is not stated by either source.Sources: hmy.com · denisonyachtsales.com
-
Crusader 454 XL (7.4L gas V8) — gas, twin
factory option
The 390 review's test boat had twin Crusader 454 XLs; rating not given in the source read.Sources: denisonyachtsales.com
-
MerCruiser 7.4L gas V8 inboard — gas, twin
factory option
Listed in the 390 review as another gas choice.Sources: denisonyachtsales.com
-
Cummins 330 hp diesel — 330 hp, diesel, twin
factory option
HMY: Cummins 330 hp diesels cruise at 20-22 kn. Search results show 1999 404s with twin Cummins 330s (listings not read).Sources: hmy.com
-
Cummins 210 or 250 hp — 250 hp, diesel, twin
factory option
The 390 review lists Cummins 210 or 250 hp diesels as options (early boats).Sources: denisonyachtsales.com
-
Volvo Penta KAMD41 / KAMD42 — diesel, twin
factory option
The 390 review lists twin Volvo Penta KAMD 41 or 42 diesels as an option; ratings not given.Sources: denisonyachtsales.com
Boats of the same model can differ — check which engines yours actually has before ordering parts.
Generator
Only one listing names a set (a Kohler 7.3 kW on a 2000 404 Cockpit Motor Yacht). The PowerBoat Guide says nothing about a generator, and no Carver option list was found.
Known problems for this model
-
Aft auxiliary tank leaks (sister-ship data) fuel
The 355/356 sister ship has a record of leaking aft auxiliary fuel tanks; check whether this boat shares the tank arrangement.boatered.com
Engines & parts
Crusader 350 / 454 inboard gas V8 parts: good
Factory optional engine — you entered “Crusader 454 XL (7.4L gas V8)”
GM-based inboard engines; Crusader (now part of Pleasurecraft Marine Engine Co.) still publishes illustrated parts manuals and sells through distributors. Go2marine stocks Crusader manifolds, risers, raw water pumps and ignition parts; Osco and Barr make aftermarket manifolds, and new GM/Crusader base engines are sold by rebuilders.
Parts sources: Crusader Engines, Go2marine (Crusader parts), 1-800-RUNS-NEW (GM & Crusader base engines)
Common problems (1)
-
Clogged or failing manifolds/risers exhaust
Owners find individual risers running much hotter than the others (a sign of internal blockage) and debate replacing vs. flushing; Osco manifolds are often preferred as closest to OEM.marineengine.com · marineengine.com
Maker’s service schedule (14)
| Engine oil & filter change 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 1 yr | “Change engine oil and filter — After 1st 25 Hrs / Every 50 Hours of Operation / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Fuel filters & water separator 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 1 yr | “Fuel Filters - Service or replace — After 1st 25 Hrs / Every 50 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Raw-water pump impeller 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Cooling System - Inspect/Replace raw water pump impeller — Every 100 Hours of Operation / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Drive belts inspect / replace 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Drive Belt - Inspect condition and check tension — After 1st 25 Hrs / Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Spark plugs inspect / replace 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Ignition System and Spark Plugs - Clean and inspect condition — After 1st 25 Hrs / Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Exhaust mixing elbow inspection 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 4 mo | “Exhaust System - Check condition and tightness of all hose clamps — After 1st 25 Hrs / Every 100 Hours(1) / Once Each Ye” — manufacturer (2013), crusaderengines.com |
| Coolant replacement & freeze-point test 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 5 yrs | “Fresh-water cooled models - Change coolant — Every five years” — manufacturer (2013), crusaderengines.com |
| Engine pencil zincs 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 mo | “Zinc Anodes - Heat exchanger and cooler - check condition — Every 30 days” — manufacturer (2013), crusaderengines.com |
| Transmission fluid change 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 yr | “Transmission and "V" Drive - Change fluid and clean strainer, if equipped — After 1st 25 Hrs (Hurth Only) / Once Each Ye” — manufacturer (2013), crusaderengines.com |
| Flame arrestor & crankcase ventilation - clean and inspect 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Flame Arrestor and Crankcase Ventilation System - Clean and inspect — Every 100 Hours / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Engine alignment check 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 1 yr | “Engine Alignment - Check and adjust if necessary — After 1st 25 Hrs / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Inspect all hoses (and cooling hose clamps) 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 1 yr | “Hoses (all) - Inspect for cracks, swelling, weather checking or other signs of deterioration — Every 100 Hours / Once Ea” — manufacturer (2013), crusaderengines.com |
| Shift & throttle cable linkage - inspect and lubricate 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 100 hrs or 4 mo | “Shift and Throttle Cable Linkage - Inspect and lubricate — Every 100 Hours(1) / Once Each Year” — manufacturer (2013), crusaderengines.com |
| Electrical system - check connections and wiring 2013 MPI 5.0L/5.7L (350 CID)/6.0L | 50 hrs or 2 mo | “Electrical System (complete) - Check for loose or dirty connections and damaged wiring — Every 50 Hours(2) / Once Each Y” — manufacturer (2013), crusaderengines.com |
Service part numbers (18)
| Oil filter remote-mounted oil filter (MP7.4L and 2013 5.0/5.7/6.0L MPI) |
Crusader 22679 | “Oil Filter 22679 (MAINTENANCE ITEM PART NUMBERS)” — manufacturer, crusaderengines.com |
| Fuel filter MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 |
Crusader 47038 | “Fuel Filter 47038 (MAINTENANCE ITEM PART NUMBERS)” — manufacturer, crusaderengines.com |
| Fuel filter 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13 |
Crusader RP080026 | “Fuel Control Cell (FCC) Fuel Filter Element RP080026” — manufacturer, crusaderengines.com |
| Fuel pre-filter / separator MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: engine-mounted Racor water-separating filter 47046 |
Crusader 47047 | “25 47047 Element, Racor fuel filter (Not Shown) 1” — manufacturer, crusaderengines.com |
| Fuel pre-filter / separator 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13: primary fuel filter |
Crusader R080033 | “Primary Fuel Filter Element R080033” — manufacturer, crusaderengines.com |
| Raw-water impeller MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 (raw water pump RA057031) |
Crusader RP061017 Replaces R061017 |
“Replaces Crusader R061017 (Impeller Kit with Gasket & O-Ring | Crusader RP061017)” — dealer, marinepartssource.com · “Replaces Crusader R061017 (Impeller Kit with Gasket & O-Ring | Crusader RP061017)” — dealer, marinesuppliesdepot.com |
| Raw-water impeller 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13 |
Crusader RP061022 | “Impeller , Raw Water Pump (1) RP061022 (ON-BOARD PARTS KIT 5.7L)” — manufacturer, crusaderengines.com |
| Raw-water pump kit MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008 (raw water pump RA057031) |
Crusader 40064 | “40064 Overhaul Kit, Major (includes items 2, 3, 11, 14 and 15)” — manufacturer, crusaderengines.com |
| Drive belt MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: alternator drive |
Crusader 98210 | “Alternator Drive Belt 98210” — manufacturer, crusaderengines.com |
| Drive belt MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: raw water pump drive |
Crusader 10258 | “Raw Water Pump Drive Belt 10258” — manufacturer, crusaderengines.com |
| Drive belt 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, left-hand (LH) rotation: serpentine |
Crusader R066028 | “Belt , Serpentine (1) R066028 (ON-BOARD PARTS KIT 5.7L (LH))” — manufacturer, crusaderengines.com |
| Drive belt 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, right-hand (RH) rotation: serpentine |
Crusader R066029A | “Belt , Serpentine (1) R066029A (ON-BOARD PARTS KIT 5.7L (RH))” — manufacturer, crusaderengines.com |
| Spark plug MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: platinum plug |
Crusader 49078 × 8 | “Spark Plugs (platinum) 49078” — manufacturer, crusaderengines.com |
| Spark plug 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13: platinum plug set |
Crusader RP030010 | “Spark Plug , Set, (Platinum) (1) RP030010 (ON-BOARD PARTS KIT 5.7L)” — manufacturer, crusaderengines.com |
| Thermostat MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: raw-water (standard) cooling, 143 F |
Crusader R026002E | “6 R026002E Thermostat (143-degree) 1 (Raw Water Cooling Components - Figure 18)” — manufacturer, crusaderengines.com |
| Thermostat MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: fresh-water (closed) cooling kit, 170 F |
Crusader 98203 | “5 98203 Thermostat (170-degree) 1 (Fresh Water Cooling Components 1)” — manufacturer, crusaderengines.com |
| Zinc / anode MP7.4L / MP454 XLi (454 MPI) - illustrated parts manual L510008: oil cooler / transmission cooler / heat exchanger |
Crusader R168005 | “24 R168005 Zinc, sacrificial 1 (Raw Water Cooling Components - Figure 18)” — manufacturer, crusaderengines.com |
| On-board spare parts kit (belt, cap, rotor, fuses, relays, plugs, impeller, fuel filters) 5.7L (350) MPI with FCC fuel system, 2007 on - 2013 owner manual L510001-13, LH rotation |
Crusader RK173089D-07 | “ON-BOARD PARTS KIT 5.7L (LH) 2007 TO PRESENT, FCC FUEL SYSTEM RK173089D-07” — manufacturer, crusaderengines.com |
From the engine maker’s parts lists, or two independent parts dealers. Numbers change with serial number and get superseded — check yours before ordering.
MerCruiser 7.4 (454) V8 gas parts: good
Factory optional engine — you entered “MerCruiser 7.4L gas V8 inboard”
GM big-block base; Marine Engine Depot and others sell 7.4 L engines and parts, and cast-iron riser kits run a few hundred dollars. Manifold and riser replacement is the main recurring expense.
Parts sources: Marine Engine Depot, Power Boat Supply
Common problems (2)
-
Manifold and riser corrosion exhaust
As with other gas marine V8s, internally rusted manifolds and risers can let water into the engine; periodic replacement is standard practice.powerandmotoryacht.com
-
Rough running and won't rev under load fuel
Common troubleshooting threads trace this to fuel delivery (filters, pump, carburetor) or ignition timing problems.justanswer.com · youtube.com
Maker’s service schedule (8)
| Engine oil & filter change | 100 hrs or 1 yr | “Most four-stroke outboards and sterndrive engines require an oil change either annually or every 100 hours of operation.” — manufacturer, mercurymarine.com |
| Fuel filters & water separator | 100 hrs or 1 yr | “The fuel filter on your engine should be inspected or replaced per the maintenance schedule in your owner's manual, usua” — manufacturer, mercurymarine.com |
| Raw-water pump impeller | 300 hrs or 3 yrs | “How often should my seawater pump impeller be serviced? Every 300 hours or 3 years, whichever comes first.” — manufacturer, mercurymarine.com |
| Spark plugs inspect / replace | 300 hrs or 3 yrs | “How often should spark plugs be changed? Every 300 hours or 3 years, whichever comes first.” — manufacturer, mercurymarine.com |
| Coolant replacement & freeze-point test closed (freshwater) cooling only | 5 yrs | “How often should coolant be changed on engines with closed cooling? Every 5 years.” — manufacturer, mercurymarine.com |
| Transmission fluid change sterndrive gear lube | 1 yr | “Gearcase lubricant in outboard and sterndrive lower units should also be changed annually or at the service interval spe” — manufacturer, mercurymarine.com |
| Lubricate steering linkage and check power-steering fluid sterndrive | 100 hrs or 1 yr | “Mercury Marine recommends lubricating the steering linkage and checking the power steering fluid level in ... MerCruiser” — manufacturer, mercurymarine.com |
| Check power trim fluid level sterndrive | 100 hrs or 1 yr | “Power trim and tilt fluid level should be checked annually or every 100 hours.” — manufacturer, mercurymarine.com |
Service part numbers (4)
| Oil filter | Mercury Quicksilver 35-866340Q03 | “Part number: 866340Q03 ... for MerCruiser sterndrive and inboard engines except V6 engines with the oil filter mounted o” — manufacturer, mercurymarine.com · “14957 FILTER, Oil (1 required per assembly) ... 35-866340Q03 - Oil Filter” — dealer, marineengine.com |
| Fuel filter carbureted engines (Rochester 4-barrel): filter inside carburetor fuel inlet |
Mercury 53336T | “For use on MerCruiser 3.0L, 4.3L, 5.0L , 5.7L and 7.4L engines with Rochester 2- and 4-barrel and MerCarb” — manufacturer, mercurymarine.com |
| Raw-water impeller Bravo sterndrive / inboard with pre-2000 engine-mounted plastic sea water pump |
Mercury Quicksilver 47-59362Q01 Also: Sierra 18-3087 |
“For MerCruiser engines with engine mounted, 2-piece, plastic sea water pumps.” — manufacturer, mercurymarine.com · “Included water Pump Impeller 59362Q01 fits Pre-2000 plastic seawater sea pumps. WILL NOT work on newer (2000+)” — dealer, midnightmarine.net |
| Thermostat standard cooling, 160 F |
Mercury Quicksilver 807252Q5 | “Thermostat 807252Q5 is for V6 and V8 MerCruiser engines ... made by General Motors (model year 1987-2016)” — manufacturer, mercurymarine.com |
From the engine maker’s parts lists, or two independent parts dealers. Numbers change with serial number and get superseded — check yours before ordering.
Volvo Penta KAD / KAMD / AQAD (KAD32–KAD44, KAD300) parts: limited
Factory optional engine — you entered “Volvo Penta KAMD41 / KAMD42”
Turbo plus clutch-engaged supercharger (compressor) engines used with sterndrives (KAD) and inboards (KAMD). Parts come through Volvo dealers and used-parts sellers; supercharger clutch and control parts are the costly items.
Parts sources: Power Products Systems (genuine Volvo Penta parts)
Common problems (2)
-
Supercharger clutch and controller faults engine
The magnetic clutch that engages the compressor fails to engage or cycles, capping rpm or causing hunting; controllers have failed repeatedly, and air leaks can mimic clutch faults.marineengine.com · forums.ybw.com · facebook.com
-
Compressor oil changes engine
The supercharger has its own oil that needs periodic changing, a maintenance item often missed.youtube.com
Maker’s service schedule (19)
| Engine oil & filter change KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 100 hrs or 1 yr | “Every 100 operating hours/At least once a year:” — manufacturer, princessklubben.se |
| Fuel filters & water separator KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Air filter / intake silencer KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Replace crankcase-ventilation filter KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Raw-water pump impeller KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Drive belts inspect / replace KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Check exhaust system KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Coolant replacement & freeze-point test KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) - anti-corrosion-agent coolant | 200 hrs or 1 yr | “If the freshwater system is filled with an anti-corrosion agent mixture it must be changed every year.” — manufacturer, princessklubben.se |
| Coolant replacement & freeze-point test KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) - glycol antifreeze coolant | 2 yrs | “If the freshwater system is filled with an antifreeze (glycol) mixture it must be changed every other year.” — manufacturer, princessklubben.se |
| Valve clearance check / adjust KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs | “Every 200 operating hours:” — manufacturer, princessklubben.se |
| Turbocharger inspection KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs | “Every 200 operating hours:” — manufacturer, princessklubben.se |
| Transmission fluid change KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) - reverse gear | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Replace propeller-shaft seal (reverse-gear installations, workshop) KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 500 hrs or 5 yrs | “Every 500 operating hours or at least every fifth year:” — manufacturer, princessklubben.se |
| Transmission fluid change KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) - DP-S drive | 100 hrs or 1 yr | “Every 100 operating hours/At least once a year:” — manufacturer, princessklubben.se |
| Transmission fluid change KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) - DP / DPX drive | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Lubricate DP drive steering bearing KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 50 hrs or 1 yr | “Every 50 operating hours/At least once a year:” — manufacturer, princessklubben.se |
| Check drive CV joint and exhaust bellows; check DP steering-cap bolt torques KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 200 hrs or 1 yr | “Every 200 operating hours or at least once a year:” — manufacturer, princessklubben.se |
| Replace drive universal joint and exhaust bellows (workshop) KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 2 yrs | “Every other year:” — manufacturer, princessklubben.se |
| Check compressor (supercharger) oil level KAD32P, KAD43P, KAMD43P (1999 instruction book 7740088; KAD44/KAMD44/KAD300 not covered) | 100 hrs or 1 yr | “Every 100 operating hours/At least once a year:” — manufacturer, princessklubben.se |
Service part numbers (7)
| Oil filter KAD/KAMD 42, 43, 44, 300 |
Volvo Penta 423135 | “p.91 "KAD/KAMD 42, 43, 44, 300" block: Oil filter — 423135” — manufacturer, volvopenta.com · “Genuine Volvo Penta Oil Filter 423135 Used on Engines Including KAD42, KAD43, KAD44, KAD300” — dealer, repowermarine.com |
| Oil filter KAD32 |
Volvo Penta 3517857 | “p.90 "MD31, TMD31, TAMD31, AQAD31, KAD32" block: Oil filter — 3517857” — manufacturer, volvopenta.com · “Suitable for: … Volvo Penta KAD32P” — dealer, ab-marineservice.com |
| Fuel filter KAD/KAMD 42, 43, 44, 300 |
Volvo Penta 21624740 | “p.91 "KAD/KAMD 42, 43, 44, 300" block: Fuel filter — 21624740” — manufacturer, volvopenta.com · “Categories: … Volvo Penta KAD/KAMD 42, 43, 44, 300 … Suitable for: … Volvo Penta KAD Volvo Penta KAMD” — dealer, ab-marineservice.com |
| Fuel filter KAD32 |
Volvo Penta 21492771 Replaces 829913 |
“p.90 "MD31, TMD31, TAMD31, AQAD31, KAD32" block: Fuel filter — 21492771” — manufacturer, volvopenta.com · “Geschikt voor Volvo Penta motoren:(TA)MD30,(TA)MD31,KAD32” — dealer, bakker-ijlst.nl |
| Raw-water impeller | Volvo Penta 21951356 Replaces 3841697, 877061 |
“p.91 "KAD/KAMD 42, 43, 44, 300" block: Impeller kit — 21951356” — manufacturer, volvopenta.com · “Volvo Penta 21951356, 3841697, 877061 … KAD32, KAD32P … KAD44P … KAD300, KAMD300” — dealer, repowermarine.com |
| Thermostat | Volvo Penta 3831424 | “# Volvo Penta KAD300-A … [THERMOSTAT KIT] Part Number: 3831424” — dealer, marinepartsexpress.com · “Volvo Penta Thermostat kit 31 41 42 43 44 Series - 3831424 … KAD300-A, KAD32P-A, KAD43P-A, KAD44P-A” — dealer, marinedustrie.com |
| Drive belt | Volvo Penta 977542 | “# Volvo Penta KAD44P-A … [V-BELT] Part Number: 977542” — dealer, marinepartsexpress.com · “Replaces Volvo Penta 977542 / KAD32P, KAD42A, KAD42B, KAD42P-A, KAD43P-A, KAD44P” — dealer, repowermarine.com |
From the engine maker’s parts lists, or two independent parts dealers. Numbers change with serial number and get superseded — check yours before ordering.
Model sources (3)
Own a Carver 390 / 400 / 404 Cockpit Motor Yacht? Add her to your boats, then share a photo — names, numbers and faces are blurred before it appears.
Other Carver models
- Carver 3207 Aft Cabin 1983–1990
- Carver 3297 Mariner / 330 Mariner 1985–1996
- Carver 355 / 356 Motor Yacht 1995–2003
- Carver 370 / 374 Voyager 1993–2002
Researched from public sources. Spotted an error? The sources are listed above — tell us what they got wrong.